MAKING AN ENVELOBOX FOR BULKY 6x6 CARD USING
THE MARTHA STEWART SCORING BOARD
This is my first attempt at tutorial so mercy, please! Besides, my
22-month old was "helping me and thus I had to rush everything resulting
is desperate photos. Hope it's of some help though!

What you need:
Sheet of
cardstock cut to 11x11 inches
If you want a
front panel, then cut it approx to 6 1/4 x 6 1/4 inches
Martha Stewart Scoring Board
ATG Gun
Scissors
Double-sided tape
1/2 inch wide ribbon (about 22 inches)
Measuring tape (for ribbon. totally optional, I just measure "by hand", lol)
Start by positioning the envelope attachment (stored on the back of the scoring board) onto the board
and placing cardstock as shown. Make sure the corner of the card is
touching the side of the board and that it sits snugly against the
bottom edge of the triangle.

Then score at 4 inches and 4.5 inches. Repeat with remaining 3 corners.
Then snip out the area marked in orange, repeat on all 4 sides:

You end up with a following result:

Score on all the lines and attach the front panel if using:

Now apply the adhesive onto the areas marked orange (sorry for wonky lines, I was is HORRIBLE rush and just used a brush tool):

Place
the cardstock "face down" now and attach together side flap and bottom
flap placing bottom flap on top. It helps if you use a book or thick 6x6
stack of cardstock inside the envelobox to help to align the corner and
sides properly. It has to be about 1/2 inches thick cause that's the
depth of the envelobox.

Now tuck the remaining side flap underneath, line it up and adhere.

And voila, here's your box!

You could stop here no problem but I like to finish off and enforce a bit more.
I attach the
double-sided tape onto the full length of the ribbon. You can do the same thing with
ATG gun
as well but NOT on tiled kitchen floor while trying to fend off 2
intensely curious toddlers, lol. The ribbon needs to be 3 times the
length of the side of your box plus about 4 inches extra. I just measure
by hand.

Peel the backing off the tape and tuck about two inches into the envelope:

Then stick the ribbon to 3 sides of your card and tuck the remaining bit into the other side of envelobox. Here's the result:

Looks
tidy, doesn't it? I just use the dirt cheap satin half inch ribbon you
can buy in spools from Ebay, no need to use your fancy ribbons!
So, here's the box:

And here's the card with the matching envelobox:

Card details can be found
HERE.
A NOTE:
If your card isn't terribly bulky but still thick enough not to fit
comfortably into a regular envelope then cut your cardstock to 10.5 x
10.5 inches and score at 4 and 4 1/4 inches. That gives you an envelobox
1/4 inches deep.
Hope it was helpful!
Thanks for reading!
Hugs
Recent Comments